Product ID:EPDM BLACK LAP SEALANT
MSDS Date:10/25/1989
FSC:8030
NIIN:LLLS70216
MSDS Number: BKRZJ

ADCO PRODUCTS INC

4401 PAGE AVE
MICHIGAN CENTER, MI 49254
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 517-764-0334

Cage: 6M737

ADCO PRODUCTS INC

MICHIGAN CENTER, MI 49254 US

Telephone: 517-764-0334

Cage: 6M737

THE SKIN WITH WATERLESS HAND CLEANERS

RTECS: 9999999ZZ

NAPHTHA, LIGHT ALIPHATIC SOLVENT

CAS: 64742-89-8

Fraction By Weight: 50% MAX

OSHA PEL 500 PPM (MFR)

ACGIH TLV: 300 PPM (MFR)

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: <1%

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.1 MG/M3 RDUST;9293

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION, REDNESS. CHRONIC:
EXPOSURE TO RESPIRABLE QUARTZ WILL NOT BE POSSIBLE WITH THIS
PRODUCT UNDER NORMAL CONDITIONS OF USE.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: GROUP 2A.
Effects of Overexposure:EYE: CAN CAUSE SEVERE IRRIT, REDNESS, TEARING,
BLURRED VISION. SKIN: CAN CAUSE REDNESS, IRRIT, DEFAT, DERMAT.
INHAL: PRLNGD INHAL OF VAPORS MAY CAUSE IRRIT OF THE RESP TRACT.
INTENTIONAL MISUSE BY DEL IBERATELY CONCENTRATING AND INHALING
VAPOR MAY BE HARMFUL/FATAL. INGEST: CAN CAUSE GI IRRIT, NAUS,
VOMIT, DIARRHEA.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN, AND
PULMONARY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES, FREQUENTLY FLUSHING UNDER LIDS. SEEK MD. SKIN: WASH WITH
SOAP AND WATER. GET MEDICAL ATTN IF IRRITATION PERSISTS. INHAL:
REMOVE AFFECTE D PERSON TO FRESH AIR, GIVE OXYGEN OR ARTIFICIAL
RESPIRATION AS NECESSARY TO ASSIST BREATHING. GET MED ATTN. INGEST:
DO NOT INDUCE VOMITING. GET MED ATTN.

Flash Point Method:TCC
Flash Point:52.0F,11.1C
Lower Limits:0.9%
Upper Limits:6.7%
Extinguishing Media:FOAM, DRY CHEM OR CO*2. WATER MAY BE INEFFECTIVE,
BUT WATER SHOULD BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
FOR ENCLSD/CONFINED SPACES/AS OTHERWISE NEEDED. TREAT AS CLASS "B"
FIRE. LIMIT (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND & BE IGNITED BY IGNIT SOURCES DISTANT FROM HNDLG POINT.
RESIDUE IN "EMPTY" CNTNRS MAY EXPLO IF EXPSD (SUPP DATA)

Spill Release Procedures:ELIM ALL IGNIT SOURCES. CONTROL SOURCE OF
SPILL IF SAFE TO DO SO. VENT ENCLOSED AREAS TO PVNT VAPOR ACCUM.
RESTRICT ACCESS BY UNAUTHORIZED PERSONNEL. ABSORB SPILLED PROD
W/VERMICULITE/OTHER ABSORB MAT L. SHOVEL/SCOOP INTO SEALABLE CNTNR
FORDISP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE/HANDLE NEAR AN IGNIT
SOURCE. KEEP CNTNRS CLSD. EFFECTIVELY GROUND PROD TRANSFER SYSTEM
TO PVNT FIRE/EXPLO FROM STATIC DISCHARGE.
Other Precautions:EMPTY CNTNRS MAY CONTAIN RESIDUAL PRODUCT. DO NOT
REUSE CONTAINERS UNLESS PROPERLY RECONDITIONED. MINIMIZE BRTHG VAP.
AVOID PRLNGD/RPTD CONT W/SKIN. REMOVE CONTAM CLTHG & LAUNDER BEFORE
REUSE.

Respiratory Protection:LRG SPILLS/ENTRY INTO CONFINED SPACES W/INADEQ
VENT, A NIOSH/MSHA APPRVD PRESS DMD, SCBA IS REC. IF
ENGINEERING/ADMIN CONTROLS ARE NOT ADEQ TO MAINTAIN SOLV TLV BELOW
REC LEVS, AN APPROP NIOSH/MSHA AP PRVD RESP SHOULD BE USED.
Ventilation:GENERAL EXHAUST AS NEEDED TO KEEP TLV BELOW RECOMMENDED
LEVELS IF ENGINEERING OR ADMINISTRATIVE CONTROLS ARE NOT ADEQ.
Protective Gloves:BUNA-N, IF NEEDED.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:CLEANSE SKIN THORO AFTER CONT, BEFORE WORK
BREAKS & MEALS, AT END OF WORK DAY. PROD IS READILY REMOVED FROM
(SEE ING 3)
Supplemental Safety and Health
FIRE FIGHT PROC:FIREFIGHTING TO THOSE TRAINED TO DO SO. IF LEAK/SPILL
HAS IGNITED, USE WATER SPRAY TO DISPERSE VAPS & TO PROT MEN ATTEMPT
TO STOP LEAK. MINIMIZE BRTHG GASES, VAP, FUMES/DECOMP PRODS. E XPLO
HAZ: TO AN IGNIT SOURCE. TO PVNT FIRE/EXPLO FROM STATIC ACCUM &
DISCHARGE, EFFECTIVELY GROUND PROD TRANSFER SYSTEM.

HCC:F3
Boiling Pt:B.P. Text:240F,116C
Vapor Pres:45 @ 78F
Vapor Density:3.8
Spec Gravity:1.16 (H*2O=1)
Evaporation Rate & Reference:9.2 (ETHYL ETHER = 1)
Solubility in Water:<0.5%
Appearance and Odor:BLACK PASTE WITH CHARACTERISTIC ALIPHATIC SOLVENT
NAPHTHA ODOR.
Percent Volatiles by Volume:45

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:IN THE EVENT OF PARTIAL COMBUSTION,
FUMES, SMOKE, CO, ALDEHYDES, AND OTHER DECOMP PRODS MAY BE
RELEASED.

Waste Disposal Methods:IF THIS PRODUCT BECOMES A WASTE, IT IS
CONSIDERED A HAZARDOUS WASTE DUE TO IT'S IGNITABILITY. DISPOSE OF
IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL ENVIRONMENTAL AND WASTE
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.